First proper rideout of the year and my gsx-r dies in the middle of no where. - Page 3 - SV650.org

Paul the 6th · 28-02-12, 01:16 PM

Quote:

Originally Posted by AndyBrad

probably karma

Mentioned karma and rickrolling in this thread: http://forums.sv650.org/showthread.php?t=175612

NTECUK · 28-02-12, 01:40 PM

Clicking is low power. So as it primed.that means low consumption the volt drop not high.
Check the connections to starter and the chassis ground.might have corroded over winter .the reg would cause charging problems but I should crank and fire up.

Paul the 6th · 28-02-12, 01:54 PM

The AA guys multimeter was showing around 12v with ignition on & off, but then voltage was dropping to 6-8 volts when trying to start (clicking). This was the same on both the old and new battery.

NTECUK · 28-02-12, 03:18 PM

THat's across the battery ?if so visual inspection of the loom to starter. If nothing obvious can you get to the starter .It's sounding like thats failed.and if its stuck in engagement thats why you can't bump it .
Might sound odd but sniff the starter .if It's acrid smelling then not good news .

28-02-12, 05:10 PM

Miles from anywhere with a flat battery...
Sounds like the last time you touched my bike...

Paul the 6th · 03-03-12, 02:35 PM

Update time...

Had Yorkie Chris, Tom the great and Owenski round this morning to try and diagnose what's up with my bike. After an hour of prodding and removing as many parts as possible, we think it might be buggered.

Starter checked, relay's checked, fuses checked, wiring checked.. lot's of stuff checked. So now the fault has been traced as far back as the engine itself - why won't it bump start? It seems to be boiling down to the engine being locked, either because a piston and valve have collided or because the bottom end (crank/piston) has gone wrong somewhere. The camchain is in good condition, the starter gearing is good, the oil is still golden on many of the internal nuts & bolts we've removed..

Still, inventing a new tool "The bastadiser" put a smile on my face.

So we're either looking at sourcing a 2nd hand running engine, or rebuilding the one which is in there depending on how shagged it is. On the bright side YC mentioned something about a GSX-R 800 if we rebuild the existing motor (and it turns out to have been a knackered bottom end).

Feck my life.. Why couldn't it have been a reg rec?

NTECUK · 03-03-12, 02:41 PM

Bummer.

Hope its sorted out soon

Paul the 6th · 03-03-12, 02:46 PM

Well there's gsx-r 750 engines on ebay going for about £350-£400, so if it's quicker and cheaper to just swap it all over with a known working engine then I'll prolly go down that route, and then keep the original engine for gsx-r 800 madness..

L3nny · 03-03-12, 02:51 PM

What a wounder. And just as the weather is warming up too.

maviczap · 03-03-12, 03:01 PM

That's shizzle luck mate

28-02-12, 01:40 PM	#22
NTECUK Member Mega Poster Join Date: Apr 2011 Location: essex Posts: 5,314	Re: First proper rideout of the year and my gsx-r dies in the middle of no where. Clicking is low power. So as it primed.that means low consumption the volt drop not high. Check the connections to starter and the chassis ground.might have corroded over winter .the reg would cause charging problems but I should crank and fire up. __________________ Raisin cookies that look like chocolate chip cookies are the reason I have trust issues.

28-02-12, 01:54 PM	#23
Paul the 6th Member Mega Poster Join Date: Mar 2007 Location: Yorkshire Posts: 4,790	Re: First proper rideout of the year and my gsx-r dies in the middle of no where. The AA guys multimeter was showing around 12v with ignition on & off, but then voltage was dropping to 6-8 volts when trying to start (clicking). This was the same on both the old and new battery. __________________ RIP Reeder 20/07/1988 - 21/03/2012 - You were awesome Cbf600, sv650, sv1000, gsxr 750 srad, KTM adventure 950, gsxr 750 k1, gsxr 750 srad, fazer 1000, zx9r ninja..

28-02-12, 03:18 PM	#24
NTECUK Member Mega Poster Join Date: Apr 2011 Location: essex Posts: 5,314	Re: First proper rideout of the year and my gsx-r dies in the middle of no where. THat's across the battery ?if so visual inspection of the loom to starter. If nothing obvious can you get to the starter .It's sounding like thats failed.and if its stuck in engagement thats why you can't bump it . Might sound odd but sniff the starter .if It's acrid smelling then not good news . __________________ Raisin cookies that look like chocolate chip cookies are the reason I have trust issues.

28-02-12, 05:10 PM	#25
speedplay Guest Posts: n/a	Re: First proper rideout of the year and my gsx-r dies in the middle of no where. Miles from anywhere with a flat battery... Sounds like the last time you touched my bike...

03-03-12, 02:35 PM	#26
Paul the 6th Member Mega Poster Join Date: Mar 2007 Location: Yorkshire Posts: 4,790	Re: First proper rideout of the year and my gsx-r dies in the middle of no where. Update time... Had Yorkie Chris, Tom the great and Owenski round this morning to try and diagnose what's up with my bike. After an hour of prodding and removing as many parts as possible, we think it might be buggered. Starter checked, relay's checked, fuses checked, wiring checked.. lot's of stuff checked. So now the fault has been traced as far back as the engine itself - why won't it bump start? It seems to be boiling down to the engine being locked, either because a piston and valve have collided or because the bottom end (crank/piston) has gone wrong somewhere. The camchain is in good condition, the starter gearing is good, the oil is still golden on many of the internal nuts & bolts we've removed.. Still, inventing a new tool "The bastadiser" put a smile on my face. So we're either looking at sourcing a 2nd hand running engine, or rebuilding the one which is in there depending on how shagged it is. On the bright side YC mentioned something about a GSX-R 800 if we rebuild the existing motor (and it turns out to have been a knackered bottom end). Feck my life.. Why couldn't it have been a reg rec? __________________ RIP Reeder 20/07/1988 - 21/03/2012 - You were awesome Cbf600, sv650, sv1000, gsxr 750 srad, KTM adventure 950, gsxr 750 k1, gsxr 750 srad, fazer 1000, zx9r ninja.. Last edited by Paul the 6th; 03-03-12 at 02:45 PM.

03-03-12, 02:41 PM	#27
NTECUK Member Mega Poster Join Date: Apr 2011 Location: essex Posts: 5,314	Re: First proper rideout of the year and my gsx-r dies in the middle of no where. Bummer. Hope its sorted out soon __________________ Raisin cookies that look like chocolate chip cookies are the reason I have trust issues.

03-03-12, 02:46 PM	#28
Paul the 6th Member Mega Poster Join Date: Mar 2007 Location: Yorkshire Posts: 4,790	Re: First proper rideout of the year and my gsx-r dies in the middle of no where. Well there's gsx-r 750 engines on ebay going for about £350-£400, so if it's quicker and cheaper to just swap it all over with a known working engine then I'll prolly go down that route, and then keep the original engine for gsx-r 800 madness.. __________________ RIP Reeder 20/07/1988 - 21/03/2012 - You were awesome Cbf600, sv650, sv1000, gsxr 750 srad, KTM adventure 950, gsxr 750 k1, gsxr 750 srad, fazer 1000, zx9r ninja..

03-03-12, 02:51 PM	#29
L3nny Member Mega Poster Join Date: May 2008 Location: MK Posts: 2,109	Re: First proper rideout of the year and my gsx-r dies in the middle of no where. What a wounder. And just as the weather is warming up too. __________________ 2015 GS 1200 Adventure

03-03-12, 03:01 PM	#30
maviczap Member Mega Poster Join Date: Mar 2007 Posts: 9,097	Re: First proper rideout of the year and my gsx-r dies in the middle of no where. That's shizzle luck mate __________________ We're riding out tonight to case the promised land Make everyday count RIP Reeder - Jolly Green Giant and comedy genius

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
Are we gonna have a rideout this year or what???	Specialone	The Madlanders	181	13-04-11 05:59 AM
The First EAR Rideout Of The Year.	Seggons	Photos	22	21-03-10 09:00 PM
so when do we all reckon the first big PM rideout of the new year will be?	Paul the 6th	Pennine Massive	23	15-01-09 09:09 PM