SV650.org - SV650 & Gladius 650 Forum - View Single Post

17-02-09, 10:58 PM

just had the same problem.mypost is about 4 down on page4
i started by disassembling the rhs switch gear,2 screws underneath.sprayed a bit wd down the tubes. This didnt solve it for me so followed the cables down to the carb behind the radiator.I found it easier to gain access to both carbs by lifting the tank and popping the air filter off to get to them.disconnected the cable then took the mechanism apart .cleaned ,greased and put back together. Took me about 2 hrs but that was just cos it was the first time id ever seen the carbs let alone took em apart.If ur a noob like me its Not as scary as you might think.Just take a pic of eveythin b4 u take them apart then u cant go wrong.
this sorted it for me hope it helps u.

17-02-09, 10:58 PM	#4
MrG650 Guest Posts: n/a	Re: Sticking throttle just had the same problem.mypost is about 4 down on page4 i started by disassembling the rhs switch gear,2 screws underneath.sprayed a bit wd down the tubes. This didnt solve it for me so followed the cables down to the carb behind the radiator.I found it easier to gain access to both carbs by lifting the tank and popping the air filter off to get to them.disconnected the cable then took the mechanism apart .cleaned ,greased and put back together. Took me about 2 hrs but that was just cos it was the first time id ever seen the carbs let alone took em apart.If ur a noob like me its Not as scary as you might think.Just take a pic of eveythin b4 u take them apart then u cant go wrong. this sorted it for me hope it helps u.