SV Talk, Tuning & Tweaking Discussion and chat on all topics and technical stuff related to the SV650 and SV1000 Need Help: Try Searching before posting |
|
Thread Tools |
22-07-16, 12:42 PM | #1 |
Member
Join Date: Jan 2010
Location: yorksire
Posts: 77
|
sv1000sk3 blowing main fuse
When out riding and bike is at 5500 rpm for any amount of time rev counter sticks at 5500 and main fuse blows put new fuse in an rev counter zeros and all electrics back to normal. This has happened couple of times any help gratefully appreciated.
|
23-07-16, 08:44 AM | #2 |
No, I don't lend tools.
Mega Poster
Join Date: Jul 2003
Location: Skunk Works, Nth London
Posts: 8,680
|
Re: sv1000sk3 blowing main fuse
If it's only ever the main fuse that pops, check all the other fuses are the correct ones. If they are, then the fault is located in one of a few quite specific areas:
Solenoid Black-red wire from the solenoid to; 1 regulator (there's two, they're doubled) 2 fuse labeled 'fuel' 3 ignition switch Ignition switch itself Orange wire from ignition switch to; 1 left switchgear 2 fuse board If the fault were further down the system, the relevant sub circuit fuse would pop, the above mentioned areas are the only ones that are protected solely by the main fuse. This of course assumes that no-one has used a screw instead of the correct fuse in one of the sub circuits. All bets are off then. The wiring in the main loom is well protected, so the fault likely lies in one of the branches that go to the above mentioned areas, check them carefully for damage before looking deeper.
__________________
If an SV650 has a flat tyre in the forest and no-one is there to blow it up, how long will it be 'til someone posts that the reg/rec is duff and the world will end unless a CBR unit is fitted? A little bit of knowledge = a dangerous thing. "a deathless anthem of nuclear-strength romantic angst" |
Thread Tools | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
blowing main fuse(30amp) | svrush | SV Talk, Tuning & Tweaking | 10 | 12-04-16 05:07 PM |
Main Fuse A' Blowing | squirrel_hunter | SV Talk, Tuning & Tweaking | 12 | 16-08-11 08:44 PM |
30 amp main fuse blowing - effects? | kevo115 | SV Talk, Tuning & Tweaking | 14 | 14-02-11 09:51 AM |
fuse keeps blowing | bobm | SV Talk, Tuning & Tweaking | 5 | 23-10-08 07:57 AM |
Main fuse keeps blowing | JMCHITTOCK | SV Talk, Tuning & Tweaking | 7 | 09-09-05 11:17 AM |