Breaking in a new SV650

[edlover889900]

I just bought a new 2007 SV650 (not the S or ABS). The dealer gave me some conflicting information about how to "break in" my new bike. One guy said that I need to keep the engine speed below ~5,000 RPMs for the first 500 miles, then below 8,000 RPMs for the following 500 miles. But another dealer said that I should "ride the bike as I normally would ... not worrying about any break in period". Does anyone have any opinions or thoughts on breaking in an SV650? What damage could result if I don't follow the suggested break in schedule (e.g., keeping my motor speed low for the first 500 to 1000 miles)? Does revving the engine above 5,000 RPMs really cause damage in the first few months of a bike's life? What specific problems could that cause?

[Beenz]

Run in by the book, however make sure that you change engine speed regularly. Don't let the engine bog down or coast either, change down a gear and let it pull a tad even if momentarily it revs above the rev cieling. Keep the engine working.

There are several views on running in and your chosen method is your choice. The important thing is that you change the oil and oil filter before or during the 600 mile service. That should drain the swarf and crud in the engine/gearbox.

Have fun. If I recall correctly you can run 70MPH in top initially then up to 95 for the remainder. After that gradually increase the revs over distance.

Hope this helps.

[edlover889900]

Thanks for the good advice! Much appreciated.

[MiniMatt]

Yeah, recently ran in a K5 that didn't get out much (had done all of 120 miles in two years). Changed the oil/filter myself as soon as I got it home, just to get the two year old sludge out (though it actually looked chip pan fresh). Did my best to keep below 6000 (though that got broken on occasion) up to the 600 mile service, oil & filter changed again. After that it's kinda been anything goes, but just trying to avoid thrashing the nuts off it.

[G]

I was told by the dealer i bought mine from to stick to the book religously until the first 600 mile service.

After this point it has full fat oil in you can ride it how you want regardless of what the book says.

I'm new to riding so have been taking it fairly easy any :smt056 honest.

[muffles]

Not an SV but I stuck to the running in schedule, it's in the book. There are plenty of opinions around about how you should do it, and people tend to offer them quite keenly! I stuck to the manufacturer's schedule because at the end of the day they are the ones offering me the warranty, no-one else.

[Baph]

IMO (strictly IMO - from the POV that I've not that long ago broken in my first big bike - my SV)...

Top end revs isn't that important, what counts, as has been mentionned before, is varying engine speed. Use different revs, different loads on the engine etc.

For the first 500 miles, I ran it by the book, never exceeding 5k RPM. God that was a boring week! (Yes, I do that distance every week on the bike.)

I think the recommendation was then for the next 500miles or so, to not go above 8k RPM. I tried to do this on the whole, but there were times I had it bouncing off the rev limiter. :D

Now 20k miles on, and it's never missed a beat, and doesn't appear to use oil. Of course, another bike may be different even when treated exactly the same as mine.

[Dicky Ticker]

Under warranty-- fully comp insurance--thrash the tits out of it--if its going to blow let Mr SUZUKI fix it--if it doesn't you will have one quick sv650

[Baph]

Under warranty-- fully comp insurance--thrash the tits out of it--if its going to blow let Mr SUZUKI fix it--if it doesn't you will have one quick sv650
I hope that was posted with sarcasam :p

After 3 engines they tell you were to go, and you walk there, not ride it.

[G]

I wouldnt like to chance it myself ha

I know they have started fitting lease cars and company vehicles with little black boxes telling technicians the life of the vehicle. Its only so long until they begin to fit these things to vehicles to void warranties.

[muffles]

Under warranty-- fully comp insurance--thrash the tits out of it--if its going to blow let Mr SUZUKI fix it--if it doesn't you will have one quick sv650

Yes I have heard that they can get information from the ECU regarding it's usage, this will go down well if/when they discover you didn't stick to the running in schedule...!

[Baph]

Yes I have heard that they can get information from the ECU regarding it's usage, this will go down well if/when they discover you didn't stick to the running in schedule...!
I'm told they can only get it from the last time the ignition was turned on though. So they can only tell how your last run out on the bike went. Unless you turn the ignition on/off again just before they look at the bike, naturally. :rolleyes:

[fizzwheel]

I was told I could exceed the recommended RPM by a 1000rpm or so as was Liz when she picked up her new SV.

A few things I found when reading up about running in.

1. Make sure the bikes properly warm before you ride it.
2. Dont let the engine labour in to high a gear.
3. Dont hold a constant throttle
4. You want to put some load on the engine so that you get the pistons and rings to bed in with the cylinder walls, so that you get a good seal in there.
5. Dont nanny the bike, just ride it how you normally would.
6. Dont miss the first service.

Remember your not just bedding in the engine, your bedding in the gearbox, scrubbing the tyres and bedding in new pads and disc's as well.

Dont take what I've said as Gospel, I'm not a mechanic, but all of the above seemed sensible to me. Theres plenty of info on the net have a google and a read and most importantly enjoy that new bike.

[Dicky Ticker]

I was joking but if you had THREE engines blow up through no fault of yours and they told me no more they would be in court pretty smartish
Three engines in the 1st year warranty must be a record

[Dicky Ticker]

In conjunction with Fizzwheels post it also lets you get accustomed to the handling of the bike without being silly----------Make sure you enjoy it

[Viney]

I just done the simple...Dont take it over 5k for until the 1st service. It may have gone over once or twice, but in general, dont thrash it. Its only 600 miles, should be able to do that in a weekend